Category Archives: recalls

Hyundai Recalls 55,000 Vehicles for Sudden Power Loss

Posted on 22 July 2024 by Ken Zino

The fuel control valve in the high-pressure fuel pump assemblies equipped in the vehicles could allow excess fuel to enter the fuel pump due to gradual wear of the FCV plunger. An air/fuel  mixture that runs too “rich” may result in a reduction or loss of motive power at low speeds, increasing the risk of a crash. The problem resulted in a recall in Korea last month. According to HMC, upon detection of a fault, the vehicle entered a “limp” drive mode that limited acceleration when exceeding 60 MPH. Continue reading →

Posted in customer satisfaction, electronics, news analysis, quality, recalls, safety | Tagged , , , , , , , , | Leave a comment

BMW Has Yet Another Airbag Shrapnel Recall

Posted on 22 July 2024 by Ken Zino

“The inflator for the driver air bag may not have been produced according to specifications by the supplier. In extremely rare cases, the air bag inflator could rupture, which could result in injury or death to vehicle occupants,” BMW claimed in the required NHTSA filing. Continue reading →

Posted in auto news, customer satisfaction, manufacturing, news analysis, quality, recalls | Tagged , , , , , , , | Leave a comment

FCA US Recalls 332,000 Vehicles for Bad Airbags

Posted on 15 July 2024 by Ken Zino

In the required filing just made public by the National Highway Traffic Safety Administration, FCA said “A disrupted connector on the buckle switch hall effect may affect the conduction on the connectors of the seat wiring and buckle which may cause the front seat air bag to not perform as expected during a crash.” The part in question was made by ZF Group in Italy as Molex part number 98817-1025. Continue reading →

Posted in customer satisfaction, manufacturing, news analysis, quality, recalls, safety | Tagged , , , , , , , , , , , | Leave a comment

Takata Airbag Shrapnel – BMW Recalls 400,000 3-Series Models

Posted on 12 July 2024 by Ken Zino

The original steering wheel may have been replaced with a sport or M-sport steering wheel equipped with a Takata inflator that can explode during deployment. An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death. Continue reading →

Posted in customer satisfaction, news analysis, recalls, safety | Tagged , , , , , , , , , , | Leave a comment

GM Recalls 2024 Colorado and Canyon Models for Fuel Leaks

Posted on 8 July 2024 by Ken Zino

General Motors is recalling ~9000 2024 Chevrolet Colorado and GMC Canyon vehicles for fuel tank leaks. The lock ring that secures the fuel pump to the fuel tank assembly may not have been fully locked during assembly by the supplier Plastic Omnium. This can cause a leak during a crash, possibly leading to a fire, according to GM recall filings released today by the National Highway Traffic Safety Administration (NHTSA). Continue reading →

Posted in auto news, customer satisfaction, manufacturing, quality, recalls, safety | Tagged , , , , , , , | Leave a comment

Ford Mustang, F-Super Duty Recalls for Steering and Brakes

Posted on 8 July 2024 by Ken Zino

The National Highway Traffic Safety Administration (NHTSA)  today made public more safety defect recalls on 2022-2023 Ford Mustangs, some 2024 Mustangs as well as 2025 F-Super Duty F-650 and F-750 pickup trucks.  The safety defects come from a variety of causes including, improper heat treating, power steering control module (PSCM) software and body control module (BCM) software. Continue reading →

Posted in auto news, customer satisfaction, electronics, engineering, manufacturing, quality, recalls | Tagged , , , , , , , , , , , | Leave a comment

Ford Motor Recalls More than 550,000 F-150 Pickups

Posted on 1 July 2024 by Ken Zino

Ford Motor Company is recalling more than 550,000 2014 model F-150 vehicles, the National High Traffic Safety Administration said today. A loss of the signal between the transmission output shaft speed sensor and the powertrain control module can cause the transmission to unexpectedly downshift into first gear at any vehicle speed. A downshift to first gear without warning could result in a loss of vehicle control, obviously increasing the risk of a crash. Continue reading →

Posted in customer satisfaction, news analysis, recalls, safety | Tagged , , , , , , | Leave a comment

NHTSA Fire Alert – Park Outside! 2020-2024 Kia Tellurides

Posted on 7 June 2024 by Ken Zino

The National Highway Traffic Safety Administration said today in a Consumer Alert that Kia America has issued a “park outside” recall for 462,869 model year 2020-2024 Telluride vehicle. There is a risk of fire while parked or driving in the vehicles. Kia is advising owners to park their vehicles outside and away from other vehicles and structures until the recall repair has been completed. Continue reading →

Posted in auto news, customer satisfaction, quality, recalls, safety | Tagged , , , , , , , , , | Leave a comment

Don’t Drive 2002-2006 Nissan and Infiniti Models

Posted on 30 May 2024 by Ken Zino

NHTSA is urging all vehicle owners to immediately check to see if their vehicle has an open Takata air bag recall. If it does, owners should contact their dealership to schedule a free repair as soon as possible and follow any warnings from the vehicle manufacturer. Nissan and Infiniti are offering free towing, mobile repair, and in some locations, loaner vehicles. Continue reading →

Posted in auto news, engineering, litigation, recalls, safety | Tagged , , , , , , , , , , , , , , | Leave a comment

Volkswagen Group Recalls ID.4 EVs for Bad Software

Posted on 27 May 2024 by Ken Zino

Volkswagen Group of America is recalling ~80,000 2021-2023 ID.4 compact electric SUVs. Bad software in the affected electric vehicles may have center displays and instrument panel displays from LG Electronics in Poland that do not boot, or that sporadically reset. This can result in loss of speedometer information or loss of rearview camera image. Continue reading →

Posted in customer satisfaction, electric vehicles, electronics, engineering, mobility company, recalls, safety | Tagged , , , , , , , , , | Leave a comment

Ford Maverick Pickups Recalled for Tail Light Failures

Posted on 6 May 2024 by Ken Zino

Ford Motor Company is recalling more than 243,000 Maverick vehicles. The Body Control Module (BCM) on 2022-2024 models may deactivate one or both rear tail-lights without warning. The problem appears to simple math error during the design phase of product development. The rear lamps use two position bulbs on a single circuit. However, the BCM current threshold was calibrated to the current draw for one bulb. This is a variation and expansion of a previous rear light recall. Continue reading →

Posted in auto news, customer satisfaction, electronics, engineering, recalls, safety | Tagged , , , , , , , , , , | Leave a comment

Hyundai Expands Genesis Sudden Power Loss Recall

Posted on 29 April 2024 by Ken Zino

“The low-pressure fuel pump assemblies in the vehicles may contain impellers that can deform under certain environmental conditions, such as high ambient temperature. Deformation of the impeller could cause the impeller to interfere with the fuel pump housing, resulting in a mechanical resistance that could lead to a shutdown of the fuel pump,” the NHTSA filing said. Continue reading →

Posted in auto news, customer satisfaction, manufacturing, news analysis, quality, recalls, safety | Tagged , , , , , , , , , | Leave a comment

Sudden Power Loss Recall – Bronco Sport, Maverick Trucks

Posted on 22 April 2024 by Ken Zino

“An insufficient calibration strategy for detecting sudden battery degradations during a drive cycle can lead to (a) a vehicle that is unable to restart after an auto start/stop event or (b) experience a stall while coming to a stop at low speed. Either may be accompanied by a loss of 12-volt accessories, including hazard lights,” Ford said in the required filing with the National Highway Traffic Safety Administration, which the Federal safety agency made public today. NHTSA prompted the recall. Continue reading →

Posted in customer satisfaction, electronics, engineering, news analysis, public health, quality, recalls, safety | Tagged , , , , , , , , | Leave a comment

NHTSA Probing Whether Ford Fire Recall is Adequate

Posted on 19 April 2024 by Ken Zino

The National Highway Traffic Safety Administration said just days after this recall was posted by AutoInformed that “The Office of Defects Investigation (ODI) reviewed Ford Motor Company’s proposed remedy for recall 24V-187 and started an investigation.” Continue reading →

Posted in auto news, news analysis, quality, recalls, safety | Tagged , , , , , , , , , , | Leave a comment

Ford Again Recalls Bronco Sport and Escape SUVs for Fires

Posted on 15 April 2024 by Ken Zino

Ford Motor Company (NYSE: F) is recalling more than 420,00 2022-2023 Bronco Sport and 2022 Escape vehicles because of engine fires. Affected SUVs are equipped with 1.5-liter engines where a fuel injector may crack and leak fuel inside the engine compartment, Ford said in the required filing that the National Highway Traffic Safety Administration made public this morning. This is an expansion of a previous fire recall since the original remedy was inadequate on what was then called the Dragon engine. Continue reading →

Posted in auto news, customer satisfaction, electronics, news analysis, public health, quality, recalls | Tagged , , , , , , , , , , , , | Leave a comment